High Voltage Battery System -- Model S

• HV Battery Assembly
  • HV Battery (AWD) - Remove And Install
    • Notes
    • Remove
    • Install
  • HV Battery (AWD) - Remove And Replace
    • Notes
    • Discharge
    • Remove
    • Install
  • HV Battery Revision -F to Revision -H (Retrofit)
    • Notes
    • Procedure
• HV Battery Enclosure
  • Cover - Front Access (HV Battery) - Remove And Install
    • Notes
    • Torque Specifications
    • Remove
    • Install
  • Cover - Front Access (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • Cover - Pyrotechnic Fuse (HV Battery) - Remove And Replace
    • Notes
    • Torque Specifications
    • Remove
    • Install
  • Cover - Rear Access (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • Flood Port - Remove And Replace
    • Notes
    • Remove
    • Install
  • Ground Cable (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • HV Battery Air Leak Test (In Vehicle)
    • Notes
    • Procedure
  • HV Battery Air Leak Test (On Table)
    • Notes
    • Procedure
• HV Battery Cooling System
  • Platter Enclosure Coolant - Drain
    • Notes
    • Procedure
  • Platter Enclosure Coolant - Drain (On Table)
    • Notes
    • Procedure
  • (Power Conversion System) Coolant - Drain
    • Notes
    • Procedure
  • (Power Conversion System) Coolant - Drain (On Table)
    • Notes
    • Procedure
  • Tube - Inlet - Coolant (Power Conversion System) - Remove And Replace
    • Notes
    • Torque Specifications
    • Remove
    • Install
  • Tube - Outlet - Coolant (Power Conversion System) - Remove And Replace
    • Notes
    • Torque Specifications
    • Remove
    • Install
  • (Power Conversion System) Coolant Leak Test (On Table)
    • Notes
    • Procedure
  • Platter Enclosure Coolant Leak Test (On Table)
    • Notes
    • Leak Test (On Table)
• HV Battery Electrical Components
  • Carrier - Connector - Front (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • Contactor - Fast Charge (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • Contactor - Negative (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • Contactor - Positive (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • Controller - High Voltage - Backup and Restore
    • Notes
    • HVC Backup
    • HVC Restore
  • Controller - High Voltage - Remove And Replace
    • Notes
    • Remove
    • Install
  • Drive Unit Inverter Diode Test
    • Notes
    • Procedure
  • Fuse - A/C Compressor (HV Battery) - Remove and Replace
    • Notes
    • Remove
    • Install
  • Fuse - Power Conversion System (HV Battery) - Remove and Replace
    • Notes
    • Remove
    • Install
  • Harness - High Voltage Controller (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • Harness - LV - Front (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • Harness - Pyrotechnic (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • HV Harness - Heat Pump (HV Battery) - Remove And Replace
    • Notes
    • Remove And Replace
  • HV Header - 6 Pin (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • HV Header - Front Drive Unit (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install
  • HV Header - Rear Drive Unit (HV Battery) - LH - Remove And Replace
    • Notes
    • Remove
    • Install
  • Power Conversion System - Remove And Replace
    • Notes
    • Remove
    • Install
  • Pyrotechnic Battery Disconnect - Remove And Replace
    • Notes
    • Remove
    • Install
  • Resistance Meter (Zero Adjust)
    • Notes
    • Zero Adjust With Alligator Clip Leads
    • Zero Adjust With Resistance Block
  • Shunt (HV Battery) - Remove And Replace
    • Notes
    • Remove
    • Install