Repair and Diagnosis: Technical Service Bulletins
- How to Find Technical Service Bulletins by Category/Symptom
- Recalls
- Customer Interest
- Engine, A/T Controls - Vehicle Creeps Idling In gear
- Engine Controls - High Cold Start Idle/MIL ON/DTC P0507
- Engine Controls - MIL ON/DTC P0606 Stored
- Engine Controls - MIL ON/DTC P0420 Is Stored
- Instruments - Fuel Gauge Reads EMPTY After Fill Up
- Brakes - Front Brake Clicking Noise
- Interior - Rear Seat Release Strap Missing/Damaged
- Interior - Rear Seat Trim Cover Won't Stay Latched
- M/T - Clutch Pedal Squeak/Twang or Notchy Feel
- Engine Controls - MIL ON/DTC PA200 (Air Fuel Ratio)
- Antitheft System - Alarm Will Not Arm/Arms By Itself
- Interior - Seat Belts Slow to Retract
- Interior - Rear Hatch Trim Panel Loose/Falls OFF
- Electrical/Lighting - DTC P1298 Set or Headlamps Dim
- Interior - Dash and/or A-Pillar Rattles
- Body - Door Lock Cylinders Bind
- Body - Creaking Noise From Right Side of Dash
- Interior - Front Seat Back Squeaking/Rubbing Noises
- Restraints - Child Seat Anchor Locating Button Missing
- Interior - Driver's Seat Rocks While Driving
- Restraints - SRS Lamp ON/DTC's 3-1 or 4-1 Set
- Body - Liftgate Rattles/Hatch Open Indicator On
- Suspension - Front End Clanking/Clunking On Bumps
- Steering/Suspension - Vehicle Pulls Left/Right
- Engine - MIL ON, DTC's P2646/P2651 Or P2647/P2652
- Superceded Bulletins
- 90-011 - 05/02/09
- 08-097 - 12/18/08
- 89-022 - 06/18/04
- Campaign - Extension of The Vehicle Warranty
- 99-018 - 04/20/06
- Campaign - Vehicle Warranty Extension
- 02-025 - 11/12/2002
- 98-019 - 05/13/05
- 06-001 - 01/16/06
- 01-077 - 01/12/05
- 98-011 - 02/05/02
- 03-032 - 12/09/03
- Campaign - Windshield Warranty Extension
- Campaign - Warranty Extension For Odometer Inaccuracy
- Body - Recommended Repair Materials
- Body - Recommended Sealers And Adhesives
- Body - Recommended Sealers/Repair materials
- Body - Windshield Cracks at Lower Corners
- Interior - Driver Seat Rocks Back and Forth
- Interior - Driver's Seat Rocks Back and Forth
- Body - Door Lock Cylinder Binds/Sticks
- Interior - 'A' Pillar/Dashboard Rattles
- Body - 'Rear Hatch Open' Lamp ON/Tailgate Rattles
- Audio/Navigation/RES - Warr. Exchange/Non-Warr. Repair
- Audio/Navigation/RES Unit - Warranty Exchange/Repair
- Audio/Entertainment/Navigation - Service/Warranty Info.
- Audio/Navigation/RES - Warr. Exchange/Non-Warr Repair
- Audio/Entertainment/Navigation - Service/Exchange
- 12-070 - 03/21/13
- Antitheft System - Immobilizer System (Type 3)
- Antitheft System - Type 3 System Operation/Programming
- Keyless Entry - Transmitter ID/Programming
- Keyless Entry - Remote Transmitter Information
- Antitheft System - Won't Arm or Arms By Itself
- Audio/Navigation/RES/iMID(R) - Warr Exchange/Non Warr Repair
- Restraints - Occupant Detection Initialization
- Campaign - OPDS Unit/Sensor Warranty Extension
- SRS - Indicator Lamp ON/Multiple DTC's Set
- Campaign - OPDS Unit Warranty Extension
- Campaign - OPDS Sensor/Unit Warranty Extension
- 07-030 - 06/15/07
- Electrical - GR8 Battery Diagnostic Station Update Info.
- Electrical - GR8 Battery Diagnostic Station Update
- Electrical - Battery Testing And Replacement
- Electrical - GR8(R) Battery Diagnostic Station Update
- Electrical - ED-18 Battery Analyzer Update Information
- Electrical - Battery Testing and Replacement
- Electrical - Battery Test Procedure/Equipment
- Battery - Testing Procedures
- Battery - Testing Procedure
- Disc Brake System - Brake Disc Refinishing Guidelines
- Brakes - Brake Disc Refinishing Guideline
- M/T - Squeak/Twang At Clutch Pedal
- M/T - Clutch Pedal Noise/Notchy Feel
- Engine Controls - Vehicle Moves Too Fast Idling In Gear
- Computers/Controls - Updating Control Units/Modules
- Computers/Controls - Module/Control Unit Updating
- Engine Controls - Updating ECM/PCM Software
- Engine Controls - MIL ON/DTC P0606 Set
- Computers/Controls - HIM Module Updating
- Engine Controls - MIL ON/DTC P0420 Stored
- Engine Controls - MIL ON/DTC P0420 Set
- Engine Controls/Emissions - OBD II DTC's and Monitors
- Engine Controls - Vehicle Creeps Idling In Gear
- Engine Controls - MIL ON/DTC P0507/High Cold Start Idle
- Engine Controls - MIL ON/DTC P0606 Is Set
- Engine Controls - MIL ON/DTC P0420 Is Set
- Computers/Controls - Updating Modules/Control Units
- Computers/Controls - Updating Control Units And Modules
- Computers/Controls - Control Unit/Module Reprogramming
- Computers/Controls - Updating Modules/Control Units
- Engine Controls - Control Module Programming Procedure
- Vehicle - Recommended Materials
- Vehicle - Recommended Service Materials
- Electrical/Lighting - Headlamps Dim or DTC P1298 Set
- Lighting - Headlamps Dim With Engine ON/DTC P1298
- Steering/Suspension - Vehicle Pulls Right/Left
- Steering/Suspension - Vehicle Pulls/Drifts To One Side
- Steering/Suspension - Vehicle Pull/Drift To One Side
- Steering - Vehicle Pulls/Drifts to the Left/Right
- Engine Controls - MIL ON/DTC P0507/High Cold Idle
- All Technical Service Bulletins
- A/T - New ATF DW-1 Available
- Campaign - OPDS Unit Warranty Extension
- Restraints - OPDS Unit Initialization Procedure
- Vehicle - Recommended Service Materials/Sealers/Lubricants
- Engine, A/T Controls - Vehicle Creeps Idling In gear
- Engine Controls - High Cold Start Idle/MIL ON/DTC P0507
- Engine Controls - MIL ON/DTC P0606 Stored
- Engine Controls - MIL ON/DTC P0420 Is Stored
- Keyless Entry - Keyless Remote Transmitter Information
- Electrical - ED-18 Battery Analyzer Update Info.
- BULLETIN CANCELLATION NOTIFICATION
- Tools - Required Special Tools And Equipment
- Fuel Supply System Service Manual Update
- ABS Indicator On With ABS DTC 54 Or No DTC(s)
- ABS DTC 51 Or 53 - Diagnostic Tip
- Instruments - Fuel Gauge Reads EMPTY After Fill Up
- Maintenance Required Indicator Doesn't Reset
- Odometer - Does It Rack Up Miles When Towed
- A/C - System Performance Testing
- A/C - Indicator Should Stay Off in Defrost Mode
- Instrument Panel - Removing Heater Temp and Mode Dial
- A/C - Poor Cooling During Hard Acceleration
- A/C - Heater Blows Cold Air, A/C Blows Warm Air
- Engine Oil Recommendations
- Gas Tank - Fuel Pump/Sending Unit Installation Tip
- Brakes - Front Brake Clicking Noise
- Blower (Heater) Motor Gets Hot and Blows A Fuse
- Wheel Bearing - Correct Installation To Prevent DTC's
- Wheel Bearings - Humming Or Growling
- Balancer Shaft Buzz Or Rattle Is Normal
- Tires- Edge Wear Is Normal
- Interior - Rear Seat Release Strap Missing/Damaged
- Interior - Rear Seat Trim Cover Won't Stay Latched
- A/T - Avoiding Fluid Contamination
- A/T - Fixing Banjo Bolt Leaks
- A/T - Do Not Remove Torque Converter From Mainshaft
- M/T - Clutch Pedal Squeak/Twang or Notchy Feel
- Engine Controls - MIL ON/DTC PA200 (Air Fuel Ratio)
- Drivetrain - Revised CV Joint Boot Band/Installation
- A/T - Stuck In Park After Throttle Body Replacement
- Catalytic Converter - Rotten Egg Smell
- Engine Controls - DTC P0420 Service Manual Revision
- Exhaust System - Catalytic Converter Noise
- Antitheft System - Alarm Will Not Arm/Arms By Itself
- Interior - Seat Belts Slow to Retract
- Driver's Air Bag - Replace Torx Bolts Properly
- Noise From The Rear When Backing Up
- Suspension - Drifting and Pulling At Highway Speeds
- Door Locks - Power Locks Cycle
- Plastic Panel Coating Now Available
- Interior and Exterior Trim - Tool To Make Removal A Snap
- Tail Gate Area - Creaking Or Popping Noise
- Rear Door - Noise From Door Latch
- Air Fresheners - Bad News For Paint Or Plastic
- Water Leak From Door. Check Rain Protector
- Front Door Inner Sash Trim Removal and Installation
- Roof Rack - Wind Noise
- Wind Noise - Simple Way To Replicate
- Accessory Security System - Troubleshooting
- Audio Unit - Electronically Retrieving Serial Numbers
- Audio Unit - Models Which Are Electronically Retrieval
- Emissions - DTC P1457 Possible Clogged Line
- Fuel Filler Cap Adapter Available For Testing Emissions
- Clearing DTCs and Setting ECM/PCM With The HDS
- Engine Controls - DTC P0171 Set
- Engine Controls - DTC P0172
- Engine Controls - Clearing DTC's
- Engine Controls - DTC P2646, P2647
- Windshield Washer Nozzle Troubleshooting
- Interior - Rear Hatch Trim Panel Loose/Falls OFF
- Windshield - Procedure To Check For Cracks
- Windshield Wipers - Blade Care and Replacement
- Engine - Oil Recommendation GF-4 Standard
- A/T Whine - Test Drive Tip
- A/T - Harsh Or Noisy Downshifts When Slowing Down
- Electrical/Lighting - DTC P1298 Set or Headlamps Dim
- Dashboard Switch Not Lit,? Replace Bulb, Not Switch
- M/T - Hard To Shift Into 1st Gear, Grinds Into Reverse
- Interior - Dash and/or A-Pillar Rattles
- Audio System - Never Play CD's With Adhesive Labels
- Body/Frame - Universal Subframe Removal Adapter
- Body - Door Lock Cylinders Bind
- Ignition/Locks - Cutting Sidewinder-Type Keys
- Body - Creaking Noise From Right Side of Dash
- Interior - Front Seat Back Squeaking/Rubbing Noises
- Restraints - Child Seat Anchor Locating Button Missing
- Body - Plastic Body Clip Removal Tips
- Tires - Tubless Tire Repair Information
- Interior - Driver's Seat Rocks While Driving
- Paint - Industrial Fallout Paint Damage
- Body - Unibody Repair Guidelines
- Music Link(R) - System Information/Diagnostics
- A/C - Refrigerant Leak Detection
- Restraints - SRS Lamp ON/DTC's 3-1 or 4-1 Set
- Body - Liftgate Rattles/Hatch Open Indicator On
- Campaign - Warranty Extension for The Windshield
- Campaign - Vehicle Warranty Mileage Extension
- Campaign - Poor Heater Output/Engine Overheat
- Suspension - Front End Clanking/Clunking On Bumps
- Steering/Suspension - Vehicle Pulls Left/Right
- Electrical - Battery Testing and Replacement Information
- Engine - Connecting Rod Damage Information
- A/C - Heater Blows Cold Air/A/C Blows Hot Air
- Interior - Vinyl Seat Cleaning Precautions
- A/T - ATF Cooler Cleaner Information
- Emissions - OBD II DTC's And Associated Monitors
- A/T - Vehicle Speed Sensor Installation Precautions
- Electrical - Battery Replacement Precautions
- Starting System - Unable To Key In Ignition Switch
- Engine Controls - Engine Stalling Diagnostic Information
- Computers/Controls - Initialization Procedure Info.
- Engine Controls - Using HDS For Diagnostics
- Engine Controls - Test Drive Precautions
- Audio System - CD/DVD Precautions
- Interior - Fabric Upholstery Wrinkle Information
- Body - Power Window Diagnostics Revision
- Body - Chrome/Stainless Trim Staining Information
- Brakes - Brake Disc Refinishing Information
- Recall 10V364000: Ignition Interlock Defect
- Recall - Ignition/Shift Interlock Defect
- A/T - Cooler Flushing Equipment Information
- Electrical - GR8 Battery Diagnostic Station Update Information
- Antitheft - Immobilizer System (Type 3) Information
- Overview
- Immobilizer System Components
- ECM/PCM
- Adding Programmed Ignition Keys
- Replacing All Programmed Ignition Keys
- Clearing Transponder Codes of Lost Programmed Ignition Keys
- Starting The Engine Without A Programmed Ignition Key
- Replacing The Immobilizer Control Unit Receiver
- Replacing the ECM/PCM
- Customer Situation and Required Items Chart
- Engine - MIL ON, DTC's P2646/P2651 Or P2647/P2652
- Computers/Controls - Updating Control Units/Modules
- Audio,Navigation, RES - Warr. Exchange/Non-Warr. Repair
- Cell Phone - Programmable HFL (HFT) Unit Update Info.