Technical Service Bulletins
- A/C Compressor
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Ambient Temperature Display Not Reading Outside Temperature At Times Or A/C Compressor Inoperative Due To Low Ambient Temperature (PIT4211D)
- Accessories & Equipment
- Adding Attachments To TAC Cases In Dealer Case Management (PIP6015)
- Concerns Or Questions Regarding Installation Of Dealer Installed Accessories (PIT3099U)
- General Motors Dealership Critical Equipment Requirements And Recommendations (05-00-89-029F)
- Information On Module Harvesting (22-NA-205)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- Accessories Control Systems
- Odometer Servicing When Odometer Cannot Be Set To Actual Mileage (PIT4720F)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip - Driver Information Center (DIC) Switch Buttons Are Inoperative (PIT4534G)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tip: Voice Recognition Errors When Using IPHONE With One Or More Emojis/Emoticons/Symbols In Contacts List (PIC5953D)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- Power Lift-Gate Inoperative With Key Off (PIT4429F)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- Red Led, No WIFI Operation, And/Or Limited ONSTAR® Module Functionality After ONSTAR Module Replacement For Another Condition (17-NA-215)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Diagnostic Tip: ONSTAR Vehicles With B101D And Symptom Codes (PIT5236H)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Information On Using MYBUICK, MYCADILLAC, MYCHEVROLET, And MYGMC Phone Applications To Control Gm Accessory Remote Start Kits (PI0360F)
- Side Detection System Unavailable Or Intermittently Side Blind Zone Stops Working (16-NA-069)
- Ambient Temperature Display Not Reading Outside Temperature At Times Or A/C Compressor Inoperative Due To Low Ambient Temperature (PIT4211D)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- UPFITTER Bulletin - Transport Mode Message/Battery Light Flashing (UI 121B)
- Fuel Gauge Fluctuation In Park Or Neutral (PIT3046G)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- Generation 9 ONSTAR® Modules Inoperative, BLUETOOTH Inoperative And Possible Battery Discharge Condition (Replace ONSTAR® VCIM) (11-08-44-003A)
- Vehicle Software Enhancements (13-00-89-003)
- Passenger Presence System (PPS) May Command Seat Belt Reminder Chime And Passenger Airbag Indicator On When Electronic Devices Or Conductive Objects Are Placed On Front Passenger Seat, DTCS 5045 Or B0074 0F May Set In PPS Module (08-09-41-007I)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Power Liftgate Diagnosis and Repair Information (08-08-66-005B)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- Air Bag, SRS
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Information Regarding Servicing Components Located Near Sir Components (16-NA-055)
- Passenger Presence System (PPS) May Command Seat Belt Reminder Chime And Passenger Airbag Indicator On When Electronic Devices Or Conductive Objects Are Placed On Front Passenger Seat, DTCS 5045 Or B0074 0F May Set In PPS Module (08-09-41-007I)
- Anti-Lock Brakes
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Information On Clunk/Thump Noise On Acceleration Once After Each Key Cycle (PI1402A)
- EBCM Wheel Speed Sensor Diagnostic Aid For Abs Message - Click Or Ratchet Noise - Service Traction Message - Service STABILITRAK Message - Service Steering Message (PIC5428G)
- Traction Control Light Flashes Under Hard Acceleration At Higher Road Speeds (16-NA-223)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Unable To Communicate With The EBCM DTC U0121 (PIT4056H)
- Anti-Theft Systems
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Requesting A New Key Code For Customer With Lost Or Stolen Keys (12-00-89-002E)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- Information On Poor, Limited, Reduced Remote Keyless Entry (RKE) Or Remote Vehicle Start (RVS) Range (PI1018A)
- Identifying / Matching Key Tags For Seat Memory Recall Operation (PIT5310)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- No Crank/No Start, Battery Discharged (Inspect Door Latches) (11-06-03-002)
- EI08028 - Intermittent, Inoperative Remote Keyless Entry (RKE) (Reprogram Key Fobs) (08-08-52-001G)
- Automatic Trans
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Driveline Clunk Noise (99-04-20-002O)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Automatic Transmission Oil Cooler Flush And Flow Test (17-NA-066)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Warranty Administration - Automatic Transmission Oil Cooler Flush And Flow Test (17-NA-066)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Automatic Transmission Oil Cooler Flow Test Essential Tool J-45096 TRANSFLOW® (03-07-30-002B)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- Vibration Analysis Worksheet (03-00-91-001I)
- Fluid Leak At Transfer Case Left Hand Weep Hole Or Between Transfer Case To Transmission Interface (Replace Transfer Case Input Shaft Seal-Left Or Transfer Case O-Ring Seal) (09-04-21-004B)
- Warranty Administration- Change in Automatic Transmission Add Condition Documentation and Claim Submission (09-07-30-018A)
- Auxiliary Emission Control Systems
- Axle Shafts
- Battery Management Systems
- Body Electrical
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Information On Reflective High Temperature Heat And/Or Insulating Tape For Wiring Harness Repairs (PIT5962B)
- Information For Electrical Ground Repair - Use New Replacement Fasteners With Conductive Finish (10-08-45-001F)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Coax Repair Kit Availability (17-NA-346)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- SES Light And Misfire With Injector Codes (PIP4924D)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Body Interior
- Procedure For Emailing Global Diagnostic System 2 (GDS2) Session Log To Gm TAC (Us And CANADA Dealers Only) (PIP4902S)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Diagnostic Tip - Driver Information Center (DIC) Switch Buttons Are Inoperative (PIT4534G)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Ambient Temperature Display Not Reading Outside Temperature At Times Or A/C Compressor Inoperative Due To Low Ambient Temperature (PIT4211D)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- UPFITTER Bulletin - Transport Mode Message/Battery Light Flashing (UI 121B)
- Radio Reprogramming Using TECHLINE/Service Programming System (SPS) - Ensuring Correct Vehicle Selection (PI1266)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Passenger Presence System (PPS) May Command Seat Belt Reminder Chime And Passenger Airbag Indicator On When Electronic Devices Or Conductive Objects Are Placed On Front Passenger Seat, DTCS 5045 Or B0074 0F May Set In PPS Module (08-09-41-007I)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Required Return Criteria of Complete Electrical Center (EC) and Body Control Module (BCM) with Integrated Electrical Center to Warranty Parts Center (WPC) (05-08-45-002E)
- Brakes Control Systems
- Information On Clunk/Thump Noise On Acceleration Once After Each Key Cycle (PI1402A)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- EBCM Wheel Speed Sensor Diagnostic Aid For Abs Message - Click Or Ratchet Noise - Service Traction Message - Service STABILITRAK Message - Service Steering Message (PIC5428G)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Unable To Communicate With The EBCM DTC U0121 (PIT4056H)
- Vehicle Software Enhancements (13-00-89-003)
- Charging Systems
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Collision/Avoidance
- Communication Devices
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Information On Communication With ONSTAR Module After CANADIAN Cellular Upgrade (15-08-73-001A)
- Diagnostic Tip: Unable To Connect To ONSTAR Or Connects Failed To Voice (PIT5389F)
- Requirements For ONSTAR Over The Air Programming And Updates (PIC6107A)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Voice Recognition Errors When Using IPHONE With One Or More Emojis/Emoticons/Symbols In Contacts List (PIC5953D)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- ONSTAR Will Not Power Up (PIC5491K)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Red Led, No WIFI Operation, And/Or Limited ONSTAR® Module Functionality After ONSTAR Module Replacement For Another Condition (17-NA-215)
- Normal Characteristic - ONSTAR Power Consumption (PIC4935F)
- Diagnostic Tip - ONSTAR Turn By Turn /TBT Feature Inoperative (PIC4801H)
- ONSTAR- Unwanted Or Phantom Phone Calls (PIC3278G)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- ONSTAR BLUETOOTH Option Availability (PIT4733K)
- ONSTAR BLUETOOTH Pairing Limit And Operational Characteristics (PIC5759B)
- Diagnostic Tip: Diagnosing Vehicles With ONSTAR DTC B101D-37 (PIC5492E)
- Diagnostic Tip: ONSTAR Vehicles With B101D And Symptom Codes (PIT5236H)
- Gm Of CANADA ONSTAR® Cellular Communication Upgrade (15-08-44-001H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- Diagnostic Tip: ONSTAR Turn By Turn Volume Has Low Or No Audio (PIT5263A)
- No Connect With Disabled Vehicle Or Dropped Calls With 1234567890 Min (PIC5050A)
- Poor Radio Hands-Free Voice Recognition Performance Or Sound Quality After ONSTAR Upgrade (PI1533B)
- Information On Coax Repair Kit Availability (PI0572C)
- 118 Error When Attempting To Configure ONSTAR, Use TBT, Or Other Data Services After 15-08-44-001 Upgrade (PIT5484A)
- Behavior Of Non-Upgraded ONSTAR® Equipped Vehicles Operating In CANADA After Decommissioning Of 2G CDMA Cellular Networks (16-NA-025)
- ONSTAR® Voice Fallback Number Update (15-NA-079)
- Diagnostic Tip: BLUETOOTH Connectivity Issues After Software Update (PIT5468)
- Caller Id Unavailable After ONSTAR Upgrade (PIT5464)
- Turn By Turn Directions Not Displayed After CANADA Upgrade (PIT5465)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- Diagnostic Tip: Unable To Connect Or Use Hands Free Calling Or No Data On The Call (Failed To Voice) (PIC4310L)
- Diagnostic Tip: CANADIAN ONSTAR Subscriber Unable To Receive Turn-By-Turn Directions While Traveling In The United States (PIT5264C)
- UPFITTER Bulletin - Info - Radio Telephone/Mobile Radio (Transceiver) Installation And Troubleshooting Guidelines (UI 119)
- Checking Smartphone BLUETOOTH Software Update Status (PIC5687D)
- Information On Requests To Add ONSTAR BLUETOOTH Option (PIT4864F)
- ONSTAR Voice Recognition Operation Issues (PIC3011H)
- Generation 9 ONSTAR® Modules Inoperative, BLUETOOTH Inoperative And Possible Battery Discharge Condition (Replace ONSTAR® VCIM) (11-08-44-003A)
- Information On Aftermarket Device Interference With ONSTAR® Diagnostic Services (08-08-46-004A)
- Whine Noise Heard When Using ONSTAR Or BLUETOOTH (Install Noise Filter) (10-08-44-005B)
- OnStar® Phone Number Concerns (Phone Number Incorrect/Assigned to Another Vehicle/Phone) That Occur During Diagnosis of OnStar® System (05-08-46-004C)
- Cooling System (Mechanical)
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Information On Ethylene Glycol In Transmission Fluid (08-07-30-035I)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Overheating, Cooling System Contaminated With Engine Oil (PIP5257E)
- Keep The Cooling System Free Of Debris And Corrosion To Prevent Premature Water Pump Failure (TT002-13)
- Cruise Control Systems
- Differentials & Drive Axles
- Driveshaft & Universal Joints
- Electronic Steering
- Engine Control Systems
- SES Light With A P2097 Or P2099 (PIP4964F)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Module Damage From Incorrect AFIT Usage On Vehicles With Direct Fuel Injection (PIP5569B)
- Diagnostic Tip: Fuel Injected Gasoline Engines Possible No Start Extended Crank No Power Or Fuel Pressure Related DTC'S (PIP5596A)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- Diagnostic Aids For Gas Engine Misfire/Rough Running With DTC P0300-P0308 And/Or DTC P050D (PIP5628G)
- Diagnostic Tip For Malfunction Indicator Lamp (Mil) Illuminated - DTC P0442 And/Or P0455 Set (21-NA-124)
- Replacement ECM Will Not Complete Programming (PIC6426B)
- Diagnostic Tips For Direct Injected Engines Hard Start Cold (PIP5180C)
- Information Assistance For HFV6 Re-Manufactured Engine Drivability Diagnosis Immediately Following Installation (PIP5528F)
- Information On Black Smoke, Rough Idle And Minimal Misfires On Cold Start (PIP5189C)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Malfunction Indicator Lamp (Mil) Check Engine Light On, DTC P182E (17-NA-084)
- DTC P0016 P0017 P0018 P0019 P0008 P0009 (PIP3423P)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- Cold Start Misfire And/Or Rough Idle - DTC P0300 May Be Set (PIP4959F)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Remanufactured Engine Misfire Diagnosis After Installation (17-NA-307)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Malfunction Indicator Lamp (Mil) - Check Engine Light On, DTC P182E (PI0269B)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Floor Wet Under Carpet/Engine Continues To Run With Key Off/Possible No Crank/No Start/Communication Loss/Various Electrical Concerns (Seal Seam) (08-08-57-003F)
- Diagnostic Tip - Vehicle Start And Stalls After Theft Deterrent Module Replacement (PIT5028B)
- UPFITTER Bulletin - Transport Mode Message/Battery Light Flashing (UI 121B)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Deceleration Misfire On All Cylinders 1400 Rpm To 1800 Rpm Diagnosis (PIP5264)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- SES Light And Misfire With Injector Codes (PIP4924D)
- Vehicle Software Enhancements (13-00-89-003)
- Information - Non-Gm Parts And Accessories (Aftermarket) (04-06-04-054D)
- Entertainment Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- XM Radio Displays Willies Roadhouse On All Channels (PIC6345)
- Diagnostic Tips: XM Audio Traffic And Travel Link Availability And Operation (PIT5353C)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Missing Channels Or No Audio On Certain XM Radio Channels (PIC5959C)
- Programming And Activation Of Replacement ONSTAR Modules (VCIM) (PIC5588C)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- Audio Muting When Listening To Some SIRIUS XM Channels Due To Interference In Some Geographic Locations (16-NA-356)
- Reporting Missing Or Inaccurate Navigation Radio Map Disc Information - Complete And Submit Feedback Form At Gm Navigation Disc Center Website (10-08-44-006D)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- XM Band Not Receiving All Channels (Preview Mode) (PIC5088F)
- XM Weather, Traffic, Or Travel Link Displaying Dashes, No Data Or Updating Message At Startup (PIC4707E)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- Diagnostic Tip: ONSTAR Turn By Turn Volume Has Low Or No Audio (PIT5263A)
- Poor Radio Hands-Free Voice Recognition Performance Or Sound Quality After ONSTAR Upgrade (PI1533B)
- Information On Coax Repair Kit Availability (PI0572C)
- Return Or Reimbursement Of Customer Owned CDS, DVDS Or Navigation Discs (05-08-44-024E)
- Diagnostic Tip: Gm Accessory Replacement Rear Video Screen Compatibility (PIT5406)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On USB Command And Control Multimedia Player Interface/List Of Supported Devices (09-08-44-013D)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Information On Eliminating Noise In Audio System When Using Portable Playback Device (06-08-44-015C)
- Accessory Pal (Personal Audio Link) Or PDIM (Personal Device Interface Module) Charging Of IPOD (12-08-44-001)
- Intermittent Black or Blank Screen, Radio Reset, Map Screen Stops Updating or Freezes, Voice Recognition Inoperative, Dead Battery (Update Navigation Radio Calibration and/or Software) (09-08-44-002G)
- Exhaust
- Exterior Body Panels
- Underbody Component Corrosion (PI0281L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Hem Flange Rust Repair (02-08-98-002H)
- Power Lift-Gate Inoperative With Key Off (PIT4429F)
- Clunk Or Pop Type Noise From Power Lift-Gate Assembly At Full Open Position (PIT5246E)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Non-Approval Of "Clipping" (Sectioning Of Two Vehicles) For Collision Repair (07-08-98-001B)
- Information On Drilling High Strength Steel Related To Collision Repair (10-08-98-002A)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Warranty Administration - Revised Exterior Labor Operations (Labor Only - No Part Replaced) And Required Warranty Claim Submission Information (11-00-89-007)
- No Crank/No Start, Battery Discharged (Inspect Door Latches) (11-06-03-002)
- Power Liftgate Diagnosis and Repair Information (08-08-66-005B)
- Squeeze Type Resistance Spot Welding/Equipment (03-08-98-002B)
- Exterior Lights
- Exterior Lamp Condensation And Water Leak Information And Replacement Guidelines (01-08-42-001Q)
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Frames, Subframes & Crossmembers
- Front Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Diagnostic Tip For Front End Clunk Type Noise Heard While Driving Over Bumps (17-NA-332)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Squawk Or Creak Type Noise From Front Of Vehicle (09-03-08-004E)
- Vibration Analysis Worksheet (03-00-91-001I)
- Clunk Or Thump Type Noise From Front Suspension (12-03-08-001)
- Fuel System
- Information On Improved Oil Filter Gasket Design For Spin-On Oil Filters Pf63 Pf64 And Pf48 (20-NA-213)
- Top Tier™ Detergent Gasoline And Top Tier™ Diesel Fuel Information And Licensed Brands (05-06-04-022Q)
- Properly Maintaining Vehicles In Dealer Inventory (21-NA-043)
- Information On Clicking/Ticking Sound/Noise Heard During Cold Start (07-06-04-025L)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Information On Clicking/Ticking Sound/Noise Heard During Cold Start (07-06-04-025K)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Fuel Gauge Does Not Go To Empty Or A Slosh Noise When Braking Or Accelerating After An Accident (PIT4712E)
- SES Light And Misfire With Injector Codes (PIP4924D)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Top Tier Detergent Gasoline (Deposits, Fuel Economy, No Start, Power, Performance, Stall Concerns) - U.S. Only (04-06-04-047L)
- Gm Fuel System Treatment Plus, Fuel Sending Unit Corrosion And Fuel System Deposits (05-00-89-078C)
- General Motors' Position Regarding Use of E 15 in Model Year 2007 and Newer Vehicles (10-06-04-015)
- Fuses & Circuit Breakers
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Accessory Power Outlet And Trailer Lighting Fuse Replacement Labor Operation N1720 Fuse Replacement (12-08-132-001E)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Gm Wiring Repair Strategy Information (13-00-89-008A)
- Intermittent No Crank/No Start, No Module Communication, Mil, Warning Lights, Vehicle Messages Or DTCS Set By Various Control Modules - Diagnosing And Repairing Fretting Corrosion (Disconnect Affected Connector And Apply Dielectric Lubricant) (09-06-03-004E)
- Gauges & Instrument Panels
- Odometer Servicing When Odometer Cannot Be Set To Actual Mileage (PIT4720F)
- Interior Cleaning - Instrument Panel (IP), Hard Or Plastic Surfaces, Seats, Carpet, Leather, Vinyl, Fabric Cleaner, Stain Remover, Restorer - Product Availability (06-00-89-029W)
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- Diagnostic Tip - Driver Information Center (DIC) Switch Buttons Are Inoperative (PIT4534G)
- Verifying Odometer Accuracy (PIC3100G)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- IPC Odometer Programming Method Quick Reference Guide (07-08-49-020O)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On Inappropriate Warranty Claims Submitted For Damaged Radios And Instrument Panel Clusters (IPCS) (08-08-44-015H)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- White Film/Residue On Vehicle Interior, Door Trim Panels And/Or Instrument Panel (IP) (PI0799A)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Engine Power Reduced Message After ONSTAR Upgrade (CANADA Only) (PIT5442)
- Fuel Gauge Fluctuation In Park Or Neutral (PIT3046G)
- Hazard Button, HVAC Or Driver Information Center (DIC) Control Buttons May Stick When Depressed (Remove Excess Material On Instrument Panel Accessory Trim Plate) (09-08-49-004A)
- General Servicing
- Headlights
- Exterior Lamp Condensation And Water Leak Information And Replacement Guidelines (01-08-42-001Q)
- Exterior Lighting Components "Tinted Or Smoked" By An Outside Vendor (15-08-42-001A)
- Low Beam Headlamp Bulb Diagnosis/Replacement (Inspect Bulb And Connector) (10-08-42-001E)
- Headlamp, Tail Lamp, License Lamp Or Fog/Driving Lamp Damage (02-08-42-001J)
- Heated Glass/Defoggers
- HVAC Control Systems
- Ac Blows Warm Or Poor Performance (PIT5099H)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On A/C Odors During Start Up In Hot Humid Climates (18-NA-271)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Air Conditioning Odor (Install Evaporator Core Dryer Kit And Apply Cooling Coil Coating) (99-01-39-004I)
- HVAC Operation During Remote Start (PIT5061C)
- Diagnostic Tips For Odor Emanating From HVAC System (PI1440)
- Hazard Button, HVAC Or Driver Information Center (DIC) Control Buttons May Stick When Depressed (Remove Excess Material On Instrument Panel Accessory Trim Plate) (09-08-49-004A)
- Gear Oil Type Odor in Interior of Vehicle (Install Cabin Filter into HVAC Module) (10-01-37-002)
- Identification
- Ignition Switch/Steering Lock
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (U.S. Only) (10-00-89-009F)
- Diagnostic Tip - Security Light On Intermittently / No Crank/No Start Or Start Stall / Keyless Access Vehicles May Display No Remote/Fob Detected / Poor Or No RKE Range / Service TPM DTC B3055, B3060, B3935, C0750, C0755, C0760, C0765, C0775 (PIC5650L)
- Intermittently Key Will Not Rotate In Door Or Ignition Lock Cylinder (PI0091B)
- Key Code Security Rules And Information On Gm KEYCODE Look-Up Application (CANADA Only) (10-00-89-010C)
- Ignition System
- Infotainment
- Updated Warranty And Policy Exchange Program For Electronic Products (U.S. And CANADA) (08-08-44-029N)
- ONSTAR Module 2G Sunset Information (23-NA-001)
- Questionnaire For BLUETOOTH Related Concerns (PIC5932B)
- Changing Turn-By-Turn Voice Response To Metric Or English Units (PIC5614B)
- Reporting Missing Or Inaccurate Navigation Radio Map Disc Information - Complete And Submit Feedback Form At Gm Navigation Disc Center Website (10-08-44-006D)
- Off Route Message During ONSTAR Turn By Turn Operation (PIC5374D)
- Radio Does Not Mute Enough When ONSTAR® Turn-By Turn Navigation Directions Are Announced (Increase Volume Setting Or Request Soft Mute Feature Change Through ONSTAR® Customer Service) (10-08-46-001C)
- Diagnostic Tip: ONSTAR Turn By Turn Volume Has Low Or No Audio (PIT5263A)
- Information On Coax Repair Kit Availability (PI0572C)
- Side Detection System Unavailable Or Intermittently Side Blind Zone Stops Working (16-NA-069)
- Turn By Turn Directions Not Displayed After CANADA Upgrade (PIT5465)
- DVD Navigation Update Program, Navigation Disc Diagnostic Aid, AVN Software Update Discs And Ordering Information (06-08-44-012G)
- Electronic Component Exchange Program Update (U.S. And CANADA Only) (03-00-89-013H)
- Information On Navigation Radio Not Displaying Accurate Vehicle Location After Radio Replacement, Power Loss Or Battery Replacement (08-08-44-023A)
- Intermittent Black or Blank Screen, Radio Reset, Map Screen Stops Updating or Freezes, Voice Recognition Inoperative, Dead Battery (Update Navigation Radio Calibration and/or Software) (09-08-44-002G)
- Interior/Exterior Trim
- Information On Proper Use Of Floor Mats (10-08-110-001L)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Front Sunroof Sunshade Will Not Latch Or Is Difficult To Latch In The Closed Position (PI0341E)
- White Film/Residue On Vehicle Interior, Door Trim Panels And/Or Instrument Panel (IP) (PI0799A)
- Headliner Wet, Water Leak From Front Or Rear Sunroof Glass Or Rear Compartment Carpet Wet (10-08-67-001C)
- Floor Wet Under Carpet/Engine Continues To Run With Key Off/Possible No Crank/No Start/Communication Loss/Various Electrical Concerns (Seal Seam) (08-08-57-003F)
- Wind Noise From Accessory Roof Cross Rails (PI1472)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Separated, Broken Or Missing Floor Mat And Carpet Retainers (Replace Buttons And Retainers) (08-08-110-016C)
- Interior/Illumination Lights
- Lubrication System
- Information On Flushing Oil Contamination From Cooling System (25-NA-052)
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Information On Engine Oil Consumption Guidelines (01-06-01-011Q)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Information On New Torque Specification And Installation Procedure For ACDELCO Spin-On Oil Filters (22-NA-009)
- Information On Overheating, Cooling System Contaminated With Engine Oil (PIP5257E)
- Engine Ticking Noise Or Oil Pressure Fluctuation On Cold Start (PIP5191C)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- Information Regarding Magnetic Drain Plugs (16-NA-117)
- Diagnostic Tips For Preventing Oil Leaks After Changing Oil And Filter (15-00-90-001)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Fuel And Oil Additives - Facts And Myths - Maximizing Gasoline Fuel Economy (05-00-89-072F)
- Diagnostic Information On Internal Engine Noise Or Damage After Oil Filter Replacement (10-06-01-003C)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Pi0411: Replacement Oil Filter Pf63 - (Mar 18, 2011) (PI0411)
- Manual Steering
- Unscheduled Supplemental Services (Including Flushing Services And Additives) And Proper Use Of Gm Simplified Maintenance Schedules (12-06-01-008B)
- Steering Wheel Oscillation While In Super Cruise Mode (24-NA-142)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Diagnostic Tip - Replacing Power Steering Cooler (PIT5165C)
- Vibration Analysis Worksheet (03-00-91-001I)
- Whine or Moan Type Noise from Power Steering System During Low Speed Maneuvers (Perform Repair as Outlined Below) (10-02-32-002A)
- Manual Trans
- Information On Driveline Clunk Noise (99-04-20-002O)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Vibration Analysis Worksheet (03-00-91-001I)
- Mechanical
- Engine Replacement After Severe Internal Engine Damage - Replace Intake Manifold (00-06-01-026R)
- Information On Internal Engine Noise Or Damage After Oil Filter Replacement (07-06-01-016J)
- Use Of Surface Conditioning Disks When Cleaning Gasket Sealing Surfaces And/Or Reused Parts (00-06-01-012N)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Engine Repair Tip For Installation Of Pistons (PI1394B)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Information On Engine Block Cracked At Head Bolt Hole Locations (23-NA-141)
- Information On Gasoline Engine Replacement Guidelines After Connecting Rod Or Crankshaft Main Bearing Damage - Replace Oil Cooler, Oil Cooler Lines, Oil Tank And Turbocharger (22-NA-074)
- Information For Engine Concerns Resulting From Lack Of Scheduled Maintenance, Improper Service Or Aftermarket Calibrations (16-NA-222)
- Diagnostic Tips For Knocking, Rattle, Squeak And/Or Squeal Type Noise From Engine - Engine Replacement Recommendations For HFV6 Gen 1 And Gen 2 (PIP5216G)
- Information On Overheating, Cooling System Contaminated With Engine Oil (PIP5257E)
- Diagnostic Tip On Avoiding Torque Converter Or Crankshaft Damage While Diagnosing Noise Concerns (PIP5640A)
- Information For Repairing Engine Front Cover Oil Leak, Sealing Surface Preparation And Applying RTV Sealant (12-06-01-003D)
- Fluid In Spark Plug Tubes, Coolant And/Or Oil Leak, Malfunction Indicator Lamp (Mil) Illuminated (PIP5095G)
- Needle Bearings Found In The Oil Pan During An Oil Change (PIP5226D)
- Information Assistance For HFV6 Re-Manufactured Engine Drivability Diagnosis Immediately Following Installation (PIP5528F)
- Alleged Cylinders Out Of Round (PIP5163E)
- Engine Ticking Noise Or Oil Pressure Fluctuation On Cold Start (PIP5191C)
- OEM And Remanufactured Engine And Automatic Transmission/Transaxle Identification (06-00-89-031E)
- Information On Front Engine Mount Service Recommendation (PI1475)
- Information On Close-Coupled Converter And Engine Replacement (06-06-01-010D)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Information On Clicking/Ticking Sound/Noise Heard During Cold Start (07-06-04-025L)
- Rough Idle Crank No Start Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves (PIP5029H)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Information Regarding Magnetic Drain Plugs (16-NA-117)
- New Design Cylinder Heads (16-NA-085)
- New Design Cylinder Heads (PIP4936C)
- Information On The Reuse Of Fasteners And The Proper Reading Of Torque Specifications (15-NA-069)
- Information On High Feature V6 Timing Chain Kits And Chain Guide Replacements, DTCS P0008, P0009, P0016, P0017, P0018 And/Or P0019 (12-06-01-009F)
- Dealer Reimbursement Procedures For CAC Tier 1 And Tier 2 Empowerment Tools: Diagnostic Fee, Short Term Rental, And Up-Front Towing (U.S. Only) (15-00-89-003)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Global Information For Gm DEXOS 1™ And DEXOS 2™, Engine Oil Specifications, Licensed Brands, And Service Fill (11-00-90-001B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Hydraulic Versus Mechanical TENSIONERS (TT001-13)
- Mechanical - Hydraulic
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Gm TAC Support Of Vehicle Vibration Complaints - U.S. And CANADA Dealers Only (PIT5214F)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Brake Lathe Calibration Procedure (VSS20040074)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Vibration Analysis Worksheet (03-00-91-001I)
- Information On Resurfacing Park Brake Portion Of Rear Brake Rotor (12-05-26-001)
- Memory Modules
- Mirrors
- Power Foldaway Mirror Glass Shakes, Flutters At Normal Driving Speeds (16-NA-075)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Mirror Glass Has Jerky Operation Or Stops During Mirror Travel (Follow Procedure Outlined Below) (10-08-64-003A)
- Information on Heated Electrochromatic Outside Rearview Mirror Performance (08-08-64-011A)
- Paint & Coatings
- Information On Paint Stain Under Protective Shipping Film (05-08-51-001L)
- PAINTLESS Dent Repair Process (99-08-51-001F)
- Properly Maintaining Vehicles In Dealer Inventory (21-NA-043)
- Hem Flange Rust Repair (02-08-98-002H)
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Application Of Anti-Corrosion Materials (01-08-51-003E)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Information On Hem Flange Sealer For Corrosion Protection (06-08-51-005C)
- Pre-Painting/Cleaning Process For TPO Plastic Fascias (08-08-51-002A)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Warranty Information-Fascia Refinish Labor Operations (10-08-62-003)
- Parking Brake System
- Passive Restraints
- Seat Belt Extender Availability (99-09-40-005H)
- Seat Belt Webbing/Latch Plate Becomes Twisted (PI0388F)
- Information Regarding Servicing Components Located Near Sir Components (16-NA-055)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Safety Belt Locking Conditions (Normal Operating Characteristic) (05-09-40-002G)
- Procedures
- Odometer Servicing When Odometer Cannot Be Set To Actual Mileage (PIT4720F)
- Vehicle Noise Diagnosis And TAC Requests For Assistance With Noise Related Complaints (PIP5358D)
- Website For AFIT, TPM, Gr8, MIT And PICO Scope Updates (PIP4723H)
- El-52800 - Diagnostic And Charge Battery Station (DCBS) - FAQS (23-NA-055)
- Variable Diagnostic Time Allowances (U.S. Only) (18-NA-263)
- Properly Maintaining Vehicles In Dealer Inventory (21-NA-043)
- Rear Suspension
- Information On Diagnosis And Replacement Of Shock Absorber And Strut Due To Fluid Leak (72-05-12)
- Information Regarding The Differences Between Fluid Leakage And Seepage (15-00-89-004G)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Clunk Noise From Rear Suspension In Cold Weather (16-NA-101)
- Diagnosing Suspension And Rear End Sway (PIT5139C)
- Vibration Analysis Worksheet (03-00-91-001I)
- Restraints Control Systems
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Diagnostic Information For Supplemental Inflatable Restraint (Sir) System, Intermittent Air Bag Indicator/Lamp Illuminated With DTC(S) B0012, B0013, B0015, B0016, B0019, B0020, B0022, B0023, B0026, B0033, B0040, B0042 Or B0044 Set (Inspect And Replace Connector Position Assurance (CPA) Retainer) (08-09-41-002H)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Information Regarding Servicing Components Located Near Sir Components (16-NA-055)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Seat Belt Buckle Latching Issues And/Or Seat Belt Warning Lights Illuminated (09-09-40-001C)
- Vehicle Software Enhancements (13-00-89-003)
- Passenger Presence System (PPS) May Command Seat Belt Reminder Chime And Passenger Airbag Indicator On When Electronic Devices Or Conductive Objects Are Placed On Front Passenger Seat, DTCS 5045 Or B0074 0F May Set In PPS Module (08-09-41-007I)
- Seats
- Information On Seat Belt Lap Anchor Inspection (24-NA-147)
- Information On Passenger Presence Sensing System (PPS Or PSS) Concerns With Custom Upholstery, Accessory Seat Heaters Or Other Comfort Enhancing Devices (06-08-50-009J)
- Eliminating Unwanted Odors In Vehicles (00-00-89-027J)
- Seat Belt Extender Availability (99-09-40-005H)
- Second And/Or Third Row Bench Seat Center Belt Buckle Plastic Is Cracked (PIT4547G)
- Creak Type Noise From Driver And/Or Passenger Seat Track Front Mounting Area (PI0521E)
- Second Row Seat "Easy Entry" Function Inoperative, Seat Won't Travel In Fore/Aft Direction, Seat Doesn't Fold Flat (Follow Procedures Outlined Below) (11-08-50-001)
- Information On Driver Or Passenger Seat Head Restraint Concerns With Comfort, Custom Upholstery Or Other Comfort Enhancing Devices (10-08-50-003A)
- Manual Seat Adjuster Bumpy Or Jerky Operation, Binds, Sticks, Seat Won't Adjust (Revise Seat Adjuster Mounting, Burnish Seat Tracks) (10-08-50-005C)
- Minor Wrinkles/Creases, Discoloration, Cigarette Burns and Customer Induced Cuts and Stains on Front and Rear Driver and Passenger Seats with Leather, Vinyl or Cloth Seat Covers (04-08-50-006D)
- Starter
- Cold Weather And Long Stand Time Battery Maintenance And Testing Tips (15-06-03-001F)
- Warranty Administration - Battery Testing And Warranty Replacement Requirements (North AMERICA Only) (03-06-03-004Z)
- Properly Maintaining Vehicles In Dealer Inventory (21-NA-043)
- Information On Vehicles Sitting Outside On Dealer Lots For Extended Periods Of Time With Hard Start Or Crank/No Start Condition (09-06-04-015C)
- Diagnostic Tip- Information For U0140 Or U0073 (BCM Appears Off Line On The High Speed Buss) (PIT4730B)
- Information On How To Prevent Inadvertent Vehicle Starting From Key Fob Or ONSTAR Mobile Application (17-NA-244)
- HVAC Operation During Remote Start (PIT5061C)
- Information On Using MYBUICK, MYCADILLAC, MYCHEVROLET, And MYGMC Phone Applications To Control Gm Accessory Remote Start Kits (PI0360F)
- Information On The Use Of Non Gm Approved Battery Chargers And Booster Packs (15-NA-030)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- UPFITTER Bulletin - Transport Mode Message/Battery Light Flashing (UI 121B)
- ACDELCO® Replacement Battery Warranty Procedures (03-06-03-003D)
- Intermittent Battery Draw Dead Battery Or HVAC Odor (PIT5066A)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Generation 9 ONSTAR® Modules Inoperative, BLUETOOTH Inoperative And Possible Battery Discharge Condition (Replace ONSTAR® VCIM) (11-08-44-003A)
- No Crank/No Start, Battery Discharged (Inspect Door Latches) (11-06-03-002)
- Intermittent Black or Blank Screen, Radio Reset, Map Screen Stops Updating or Freezes, Voice Recognition Inoperative, Dead Battery (Update Navigation Radio Calibration and/or Software) (09-08-44-002G)
- Steering Column
- Steering Wheel Oscillation While In Super Cruise Mode (24-NA-142)
- Proper Wheel Installation And Wheel Torque Techniques (12-03-10-002A)
- Information On Inadvertent Steering Wheel Control (SWC) Button Press Causing Radio Anomalies (08-08-44-028A)
- Squeak / Rattle Noise From Steering Column (Align Arrow On Rubber Grommet With Line On Dash Mat) (09-02-34-001B)
- Steering Control Systems
- Steering Gear
- Grease Or Sealant Visible On Electronic Power Steering Gear - Should Not Be Interpreted As Leak (16-NA-109)
- Power Steering Noise Or Fluid Leak From Power Steering Pump, Gear Or High Pressure Hose During Extreme Low Temperature Operation (Replace Power Steering Fluid) (12-02-32-002B)
- Change Power Steering Fluid To DEXRON®-VI When Replacing Steering Gear Assembly (PI0620A)
- Diagnostic Tips For Steering Gear Boot Stains, Perceived Fluid Leak From Power Steering Gear End Seals (12-02-32-004A)
- Hydraulic Power Steering System Leak - Required Diagnostic Actions (07-02-32-002M)
- Sun Roof/T-Top/Convertible Top
- Rear And Side Tempered Glass Spots (Quench Marks) (PI0754G)
- Intermittent Sunroof Operation, Bind, Noise, Auto-Reverse, And/Or Water Leaks (PIC5260F)
- Front Sunroof Sunshade Will Not Latch Or Is Difficult To Latch In The Closed Position (PI0341E)
- Headliner Wet, Water Leak From Front Or Rear Sunroof Glass Or Rear Compartment Carpet Wet (10-08-67-001C)
- Corrosion Protection For Metal Panels With Dealer Installed Accessories Fastened By Drilled Holes (03-00-89-008F)
- Suspension Control Systems
- System
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Module Damage From Incorrect AFIT Usage On Vehicles With Direct Fuel Injection (PIP5569B)
- Diagnostic Tip: Fuel Injected Gasoline Engines Possible No Start Extended Crank No Power Or Fuel Pressure Related DTC'S (PIP5596A)
- Information On Sag Or Hesitation On Acceleration (PIP4112S)
- Diagnostic Tips For Direct Injected Engines Hard Start Cold (PIP5180C)
- Diagnostic Tips For I/M Flags Resetting After Ignition Cycled (PIP5627)
- SES Light With Fuel Trim And Or Oxygen Sensor Codes (PIP4925B)
- Malfunction Indicator Lamp (Mil) Check Engine Light On, DTC P182E (17-NA-084)
- DTC P0016 P0017 P0018 P0019 P0008 P0009 (PIP3423P)
- Information On Engine Oil Life Monitor Operation Calculation (PIP5282A)
- Cold Start Misfire And/Or Rough Idle - DTC P0300 May Be Set (PIP4959F)
- Automatic Transmission Shift And Engine DRIVEABILITY Concerns And/Or Mil On Due To Aftermarket Oil Bath Air Filter Use (04-07-30-013D)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Remanufactured Engine Misfire Diagnosis After Installation (17-NA-307)
- Information On Rough Idle, Crank No Start, Extended Crank Or Misfire Due To Excessive Carbon On Top Of The Valves Or Sticking Valves, Malfunction Indicator Light (Mil) Illuminated - DTC P0300, P0301, P0302, P0303, P0304, P0305, P0306, P0307, P0308 Set (16-NA-383)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Malfunction Indicator Lamp (Mil) - Check Engine Light On, DTC P182E (PI0269B)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Premature Catalytic Converter Failures - DTC P0420, DTC P0430 (PIP5232C)
- Usage Of E85 Fuel In Gm Vehicles (05-06-04-035E)
- Floor Wet Under Carpet/Engine Continues To Run With Key Off/Possible No Crank/No Start/Communication Loss/Various Electrical Concerns (Seal Seam) (08-08-57-003F)
- Diagnostic Tip - Vehicle Start And Stalls After Theft Deterrent Module Replacement (PIT5028B)
- UPFITTER Bulletin - Transport Mode Message/Battery Light Flashing (UI 121B)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Deceleration Misfire On All Cylinders 1400 Rpm To 1800 Rpm Diagnosis (PIP5264)
- Information On Clicking/Ticking Sound/Noise Heard During Cold Start (07-06-04-025K)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Vehicle Software Enhancements (13-00-89-003)
- Towing
- Transfer Case
- PQC Assembly Replacement Process - For Dealers Required To Contact PQC Prior To Replacing An Assembly (U.S. And CANADA Only) (99-07-30-020)
- Fluid Leak At Transfer Case Left Hand Weep Hole Or Between Transfer Case To Transmission Interface (Replace Transfer Case Input Shaft Seal-Left Or Transfer Case O-Ring Seal) (09-04-21-004B)
- Transmission Control Systems
- Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (13-08-116-001K)
- Module Damage From Incorrect AFIT Usage On Vehicles With Direct Fuel Injection (PIP5569B)
- Information On Changes To SPS That Warn/Prohibit Reprogramming A Module With Its Current Calibration (17-NA-242)
- Security Code Input Message With SPS Error Code E5659, M5304 And/Or M5530 During TIS2WEB Programming (17-NA-067)
- Procedure To Take Snapshot Data With A Tech 2 And Upload Data To A Computer Using TIS Software (07-07-30-010D)
- Prior To Any Circuit Testing (PIP5094A)
- UPFITTER Bulletin - Aftermarket ALDL Or DLC Interface Devices Causing Multiple Issues (UI 108D)
- Control Module Diagnostic Trouble Code(S) (DTC)(S) P0601, P0602, P0603, P0604, P0606, P062F, P1621, P16F3 Shared In Multiple Modules (05-06-04-060A)
- Vehicle Software Enhancements (13-00-89-003)
- Wheel Alignment
- Refinishing Aluminum And Chrome Wheels (99-08-51-007G)
- Information On Slight Or Mild Tire Feathering And Recommended Practices (Normal Tire Wear Condition) (07-03-10-008E)
- Wheel Alignment Specifications, Requirements And Recommendations For Gm Vehicles (05-03-07-009H)
- Diagnosing Suspension And Rear End Sway (PIT5139C)
- Wheels & Tire System
- Tire Sidewall Irregularities (PIT4261J)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006I)
- Guidelines When Changing Tire And Wheel Size (PIT3271P)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5601B)
- Gm TAC Support Of Vehicle Vibration Complaints - U.S. And CANADA Dealers Only (PIT5214F)
- Vibration Shortly After Tires Are Mounted/Preventing Vibration From Wheel Slip (Tire Sliding On Wheel) (12-03-10-001E)
- Information On Proper Tire Pressure (00-00-90-002M)
- Information On Tire Radial Force Variation (RFV) (00-03-10-006P)
- Properly Maintaining Vehicles In Dealer Inventory (21-NA-043)
- Vehicle Vibration Diagnosis And TAC Requests For Assistance With Vibration Related Complaints (PIP5338B)
- Information On Hunter Road Force Balancer (17-NA-170)
- Non-Design Intent Wheel Lock Nuts And Lug Nuts (17-NA-126)
- Tire Slowly Goes Flat, Tire Air Loss, Low Tire Pressure Warning Light Illuminated, Aluminum Wheel Bead Seat Corrosion (Clean And Resurface Wheel Bead Seat) (08-03-10-006H)
- Information On Slight Or Mild Tire Feathering And Recommended Practices (Normal Tire Wear Condition) (07-03-10-008E)
- Information On Tire/Wheel Characteristics (Vibration, Balance, Shake, Flat Spotting) Of Gm Original Equipment Tires (03-03-10-007J)
- Abnormal Noise And Or Vibration While Driving Due To Non-Gm Aftermarket Accessory (PIP3140G)
- Use Of Nitrogen Gas In Tires (05-03-10-020F)
- UPFITTER Bulletin - Properly Maintaining Vehicles In Dealer Inventory (UI 100B)
- Statement On Tire Sealant Included In Gm Inflator Kits (Supplied With New Vehicles Or As Gm Accessory) (09-03-10-013B)
- Proper Wheel Installation And Wheel Torque Techniques (12-03-10-002A)
- Dealership Service Consultant Procedure As Vehicle Comes Into Service Drive For Tire Pressure Monitor (TPM) System Message, Light And Customer Information (09-03-16-002B)
- Wheel Balancing Machine Finish Damage To Chrome Clad Or CHROMETECH® Wheels (09-03-10-016A)
- General Motors New Vehicle Wheel Warranty Coverage (07-03-10-015B)
- Guidelines for Using Labor Operations E0200, E0201, E0203, E0204 - Wheel Balance (72-05-03)
- TPMS System Service and Re-Learning Sensor IDs (10-03-16-001)
- 20 Inch Accessory Wheels Available Through GM Accessories (07-03-10-005E)
- Information on Proper Wheel Changing Procedures and Cautions (06-03-10-010A)
- Low Tire Pressure, Leaking Cast Aluminum Wheels (Repair with Adhesive Sealant) (93-U-57)
- Tire Puncture Repair Procedures For All Cars and Light Duty Trucks (04-03-10-001F)
- TPM System Overview, Diagnosing Tire Pressure Monitor System (TPM) Concerns and TPM Frequently Asked Questions (FAQ) (07-03-16-004C)
- Mounting, Balancing And Installation Of Accessory Wheels And Tires Available Through Gm Accessories (08-03-10-004A)
- Window Motors & Regulators
- Repair Information For Reconnection Of Rear Window (Defroster) Contact Or Tab (03-08-48-006J)
- Front Or Rear Side Door Window Binds, Moves Slowly, Makes Rattle/Squeak Noise, Poor Fit/Misalignment Or Is Inoperative (PI0018B)
- Information On Body Control Module (BCM) Grounds (07-08-47-004E)
- Rear Window Defogger - Broken Heating Grid Detection Method (04-08-48-001D)
- Distortion in Outer Surface of Vehicle Glass (00-08-48-005D)
- Wiper/Washer Systems
- Wiring Diagrams
- Wiring System (Data Link Connectors, Pwr Dist., Grnd Dist.)
- J-35616-64B Or El-35616-58 Terminal Test Probe Information/Repair (PIT5074R)
- Diagnostic Tip: Apple Device Connectivity Issues Due To USB Cord Concern (PIT5399A)
- Intermittent Malfunction Indicator Lamp (Mil) Illuminated, DTC P2138 With Reduced Engine Power (Repair Instrument Panel (IP) To Body Harness Connector) (07-06-04-019F)
- Information On Coax Repair Kit Availability (17-NA-346)
- Prior To Any Circuit Testing (PIP5094A)
- Information On Coax Repair Kit Availability (PI0572C)
- Intermittent Abs Codes, No Communications, No Start And/Or Various Electrical Concerns (PIT4946A)
- Gm Wiring Repair Strategy Information (13-00-89-008A)